Suzuki Forum

Suzuki For You

P0230 - Fuel Pump Primary Circuit

Discussion about the Grand Vitara 4x4 range, including the GV1600 - 3 door, GV2000 - 5 door and XL-7 - 7 seater (1998 to 2005 models)

Moderators: wade, ClubCappo, IanL

P0230 - Fuel Pump Primary Circuit

Postby craig8661 » Mon Oct 26, 2009 8:41 pm

just wondering it had last year a new high pressure pump and a maf sensor. by sods law its 7 weeks out of warranty light came on today and is reading p0230.
it has been mentioned to pull a sencor out and clean it which one is it. here is a couple Ive seen on my engine
this is the high pressure pump back.
Image

this is at the back of the fuel rail.
Image
if its one of these how hard is it to remove it and clean it?
also car had been stood not run for around 8 weeks maybe 12.
fresh diesel in it it is the rhz engine.
craig8661
Addicted
 
Posts: 229
Joined: Mon Jul 21, 2008 9:25 pm
Location: larne northern ireland

Postby craig8661 » Tue Oct 27, 2009 12:42 pm

just to add the only other thing replaced when the clutch was done was the crankshaft sensor not exact same part number.
engine light is of at the min but will see when i take it out later on today
craig8661
Addicted
 
Posts: 229
Joined: Mon Jul 21, 2008 9:25 pm
Location: larne northern ireland

Postby craig8661 » Tue Oct 27, 2009 11:36 pm

new fault now when started and left to tick over it stalls after a few Min's then wont restart leave a little while and all is OK.
went to garage where i got the sensor from and had a look at a blown rhz engine that was out of a Peugeot seen the sensor on the high pressure pump and been told to take it out clean it if that don't work replace it at £120.
i can borrow other sensors too but he said mine points to the one on the back of the pump.
craig8661
Addicted
 
Posts: 229
Joined: Mon Jul 21, 2008 9:25 pm
Location: larne northern ireland

Postby craig8661 » Wed Oct 28, 2009 6:40 pm

sorted out
craig8661
Addicted
 
Posts: 229
Joined: Mon Jul 21, 2008 9:25 pm
Location: larne northern ireland

Postby Celtic 4x4 » Wed Oct 28, 2009 9:25 pm

Just a dirty sensor?
Celtic 4x4
Point of no return
 
Posts: 169
Joined: Sun Feb 22, 2009 1:35 pm
Location: South Wales (UK)

Postby craig8661 » Wed Oct 28, 2009 11:09 pm

nope black slime in the diesel filter replaced the filter all is well.
one thing is i have to buy a new filter top or housing for the filter as wont be able to get it back together very easy next time as the plastic nut has rounded of jeep is in for mot tomorrow then after that im dropping the tank and cleaning it out
craig8661
Addicted
 
Posts: 229
Joined: Mon Jul 21, 2008 9:25 pm
Location: larne northern ireland


Return to Suzuki Grand Vitara (98-05)

Who is online

Users browsing this forum: Baidu [Spider] and 2 guests